Steel Choker Rigging Chart - Frances K. Schreiner

Steel Choker Rigging Chart – Wire rope sling capacity chart. Rated capacities shown apply only to 6×19 and 6×37 classification wire rope rated capacities basket hitch based on. Crosby's full catalog and product listing of the wire rope sling capacities. In a choker hitch, slings shall be long enough so that the choker fitting chokes onto the sling eye or body and never onto any fittings.

Figure 119.Proper Position Of Choker Hitches For Lifting.

Steel Choker Rigging Chart

Do not inspect a sling by passing bare. At 0o, the sling stress. 1 and 2) show how a 5/8 dia.

This Chart Illustrates How The Stress In A Sling Increases As The Angle Increases (All Angles Are Measured From The Vertical).

Capacity charts for various lifting methods and specification requirements You should only use a choker hitch when the load will. Read warning and use limitations before rigging never exceed published working load limit • never rig a sling leg angle of less.

These Slings Are Made In.

Chain & lever hoists for lifting & rigging. Introduction the three main parts to any load lifting operation are the lifting equipment (crane/derrick/ hoist), the operator/operation of the equipment, and the rigging of the. Refer to the effect of angle chart in the general information section of this catalog.

The Sling Angle Must Be Taken Into Account When Determining The Proper Sling And Angles Used To Make An Overhead Lift (90°, 60°, 45°, 30°).

Choker hitches reduce the lifting capability of a sling since the wire rope component’s ability to adjust during the lift is affected. Minimum sling length when using standard eyes. Industry leading technical data for our locally prepared slings.

Nylon, Sisal, Manila, Poly & More.

Basket hitch capacity based on. Steel on steel continuous lubricated 0.05 load on air ≤0.01 0.10 0.15 cast iron on steel wood on metal leather on metal manila rope on 0.25 0.30 0.40 0.40 0.45 0.50 0.60. Free shipping on orders $199+

Wire Rope Load Limits Rated Load Based On Pin Diameter No Larger Than One Half The Natural Eye Length Or Not Less Than The Nominal Sling Diameter.

It requires persons who perform rigging or operate hoisting equipment to be trained to ensure that the personnel are competent to perform the operation. When one sling leg lifts 1,000 lbs. Rated load for grade 80 alloy steel chain slings choker hitches [note 2] nominal chain size single leg slings double leg bridle slings single basket slings.